IMT Model 1014A Crane Parts and Specifications 99901221

Table of Content:

1 ELECTRONIC MANUALS
2 INTRODUCTION
3 SPECIFICATIONS
3.1 GENERAL
3.2 PERFORMANCE CHARACTERISTICS
3.3 CYLINDERS
3.4 POWER SOURCE
3.5 ROTATION SYSTEM
3.6 CYLINDER HOLDING VALVES
3.7 EXCESSIVE LOAD LIMIT SYSTEM (ELLS)
3.8 WINCH
3.9 HYDRAULIC SYSTEM (PTO Driven)
3.10 ELECTRO-HYDRAULIC SYSTEM (2-SPEED/AUTO-SHIFT)
3.11 CONTROLS
3.12 MINIMUM CHASSIS SPECIFICATIONS
3.13 GEOMETRIC CONFIGURATION
3.14 CAPACITY CHART
4 CRANE REFERENCE
4.1 MAJOR CRANE ASSEMBLIES
4.2 WELDMENT PART NUMBER LOCATIONS
4.3 GREASE ZERK LOCATIONS AND LUBRICANT REQUIREMENTS
4.4 RECOMMENDED SPARE PARTS LIST
4.5 GENERAL INSTALLATION
4.6 CHASSIS INFORMATION
4.7 MOUNTING HOLE LAYOUT
4.8 CRANE INSTALLATION
4.9 BODY REINFORCEMENT
4.10 CONTROL VALVE TROUBLESHOOTING
4.11 RELAY BOARD OPERATION
4.12 FIGURE 1. BOTTOM VIEW OF RELAY
4.13 FIGURE 2. INTERNAL WIRING
4.14 OPERATION
4.15 IGNITION “ON”
4.16 REMOTE STARTING THE VEHICLE
4.17 REMOTE ENGINE STOP
4.18 FIGURE 3. RELAY BOARD – COMPONENTS & WIRING
4.19 REMOTE ENGINE SPEED (FROM CRANE)
4.20 FIGURE 4. REMOTE CONTROL HANDLE
4.21 FIGURE 5. REMOTE STARTING OF VEHICLE – IGNITION “ON”
4.22 FIGURE 6. SPEED CONTROL – COMPRESSOR ONLY
4.23 INSTALLATION
4.24 FIGURE 7. RELAY BOARD (77041378) WIRING INSTRUCTIONS
4.25 Excessive Load Load System (ELLS) TEST PROCEDURE
4.26 ELLS TROUBLESHOOTING PROCEDURE
5 PARTS
5.1 PARTS INFORMATION
5.2 GENERAL
5.3 CRANE IDENTIFICATION
5.4 SERIAL NUMBER PLACARD
5.5 CYLINDER IDENTIFICATION
5.6 WELDMENT IDENTIFICATION
5.7 ORDERING REPAIR PARTS
5.8 CYLINDER PART NUMBER LOCATION
5.9 BASE ASM (41704562)
5.10 MAST ASM (41714276)
5.11 WINCH/CABLE/HOOK KIT (41714331)
5.12 CABLE & HOOK KIT (31710164)
5.13 SPEED REDUCER (70057663)
5.14 CORD REEL ASM (51713168)
5.15 LOWER BOOM ASM (41714699)
5.16 LOWER BOOM CYL (3B111980)
5.17 COUNTERBALANCE VALVE ASM (73540057)
5.18 LOWER BOOM ASM-W/D-RING (41715072)
5.19 EXT BOOM ASM-HYD 10′ (41714446)
5.20 EXTENSION CYL (3B311970)
5.21 EXT BOOM ASM-HYD 14′ (41714447)
5.22 DECAL KIT-PWR UNIT (95714753)
5.23 DECAL KIT-PTO (95714752)
5.24 HYD PWR UNIT-DC (73051957)
5.25 HYD KIT-PWR UNIT (91715095) PRE 4-1-00
5.26 HYD KIT-PROP’L PTO (91715097) PRE 4-1-00
5.27 HYD KIT-NON-PROP’L PTO (91715099) PRE 4-1-00
5.28 HYD KIT-RADIO RMT (91715579)
5.29 HYD KIT-NON-PROP’L PTO (91715657) EFF: 4-1-00
5.30 HYD KIT-PWR UNIT (91715654) EFF: 4-1-00
5.31 HYD KIT-PROP’L PTO (91715656) EFF: 4-1-00
5.32 INSTALLATION KIT-PWR UNIT (93714530)
5.33 INSTALLATION KIT-PTO MTG HARDWARE (93715346)
5.34 CONTROL KIT-PWR UNIT (91714438)
5.35 CONTROL KIT-NON PROP’L PTO (91714439)
5.36 CONTROL KIT-PROP’L PTO (91714440)
5.37 CONTROL KIT-RADIO RMT (90715576-1)
5.38 CONTROL KIT-RADIO RMT (90715576-2)
5.39 SCHEMATIC-PWR UNIT (99901153)
5.40 SCHEMATIC-PWR UNIT (99901153)
5.41 SCHEMATIC-PROPORTIONAL RMT CTRL (99900990)
5.42 SCHEMATIC-NON PROP’L RMT CTRL (99901049)
5.43 VALVEBANK-PROP’L RMT CTRL (70733222-1) PRE 4-1-00
5.44 VALVEBANK WIRING HARNESS (70733222-2) PRE 4-1-00
5.45 VALVEBANK-PWR UNIT (70733225-1) PRE 4-1-00
5.46 VALVEBANK WIRING HARNESS (70733225-2) PRE 4-1-00
5.47 VALVEBANK-NON PROP’L (70733346-1) PRE 4-1-00
5.48 VALVEBANK WIRING HARNESS (70733346-2) PRE 4-1-00
5.49 VALVEBANK-NON PROP’L (70733400) EFF: 4-1-00
5.50 VALVEBANK WIRING HARNESS (70733394) EFF: 4-1-00
5.51 VALVEBANK-PWR UNIT (70733398) EFF: 4-1-00
5.52 VALVEBANK-PROP’L RMT CTRL (70733399) EFF: 4-1-00
5.53 VALVEBANK-4 SECTION (73733382)
5.54 VALVEBANK ASM-2 SECTION (51705983)
5.55 VALVEBANK ASM-3 SECTION (51705984)
5.56 RMT HANDLE ASM-PWR UNIT (51714700)
5.57 RMT HANDLE ASM-PTO (51713384)
5.58 RMT HANDLE ASM-PTO (51713182)
5.59 HANDLE ASM-RADIO RMT (51715567)
5.60 OPTION-BOOM SUPPORT/RESERVOIR 20 GAL (51706910)
5.61 OPTION-RESERVOIR 18 GAL-BULKHEAD (51707798)
5.62 AUX OUTRIGGER-REAR-MNL OUT & DN (31711125)
5.63 AUX OUTRIGGER-MNL OUT/CRANK DN (31711126)
5.64 AUX OUTRIGGER-MNL OUT/PWR DN (31711127)
5.65 AUX OUTRIGGER-PWR OUT/PWR DN 5X5 (31711128)
5.66 CYLINDER-PWR DN (3B288970)
5.67 CYLINDER-PWR OUT (3B142860)
5.68 CABLE ASM-RADIO RMT BACKUP (73733374)
5.69 CABLE ASM (70733351-1)
5.70 CABLE ASM (70733351-2)
5.71 SCHEMATIC (99903131)
5.72 RADIO RMT KIT (70733354-1)
5.73 RADIO RMT KIT (70733354-2)
6 GENERAL REFERENCE
6.1 INSPECTION CHECKLIST
6.2 WIRE ROPE INSPECTION
6.3 HOOK INSPECTION
6.4 HOLDING VALVE INSPECTION
6.5 ANTI-TWO BLOCKING DEVICE INSPECTION
6.6 TORQUE DATA CHART – DOMESTIC
6.7 TORQUE DATA CHART – METRIC
6.8 TURNTABLE BEARING FASTENER TIGHTENING SEQUENCE
6.9 TURNTABLE BEARING INSPECTION FOR REPLACEMENT
6.10 LIMITED WARRANTY
7 TELESCOPIC CRANE VOLUME 1