Claas ARION 430-410 (A21) Tractors Repair Manual PL

File List:

– 00 1143 681 0.pdf
– Size(0.4 MB) 1.26.2010.pdf
– Size(0.7 MB) 11/10/2009.pdf
– Size(1.6 MB) 7/27/2011.pdf
– Size(1.9 MB) 11/25/2009.pdf
– Size(2 MB) 11/10/2009.pdf
– Size(2.3 MB) 11/10/2009.pdf
– Size(2.7 MB) 1.26.2010.pdf
– Size(25 MB) 2/17/2010.pdf
– Size(28.8 MB) 7/27/2011.pdf
– Size(3.2 MB) 2/2/2010.pdf
– Size(3.3 MB) 11/25/2009.pdf
– Size4.port specific torques)
5.1 Bolt class
5.2 Hydraulic fittings of DIN 3865

Size(0.7 MB) 11/10/2009.pdf

Table of Content:
1 03CHASSIS
1.1 FRONT AXLE WITH WHEELSDRIVEN

Size(1.6 MB) 7.27.2011.pdf

Table of Content:
1 ERROR CODES
1.1 Introduction
1.2 Displaying fault codes
1.3 Error Code List Description
1.4 Error Code List

Size(1.9 MB) 11/25/2009.pdf

Table of Content:
1.1 WORK BRAKE
1.2 BRAKEAIRTRAILERS
1.3 BRAKEHYDRAULICTRAILERS

Size(2 MB) 11/10/2009.pdf

Table of Content:
1 05STEERING
1.1 Settings
1.2 Specific moments and fastening means
1.3 Measurements and controls 60 and 98 l/min
1.4 Reading cards 60 and 98 l/min

Size. KIT
1.1 TOOLKIT BY CHAPTER
1.2 REFERENCE TOOLKIT

Size(25 MB) 2/17/2010.pdf

Table of Content:
1 02TRANSMISSION AND CLUTCH
1.1 02 00GENERAL
1.2 02 10″REVERSHIFT”
1.4 02 30MECHANICAL REDUCER
1.5 02 34 REDUCER UNDER LOAD “QUADRISHIFT”
1.6 02 40REAR AXLE HOUSING IFINAL GEARS
1.7 02 42DIFFERENTIAL ICENTRAL GEAR
1.8 02 52 ELECTROHYDRAULIC TRANSMISSION SHAFT

Size(28.8 MB) 7/27/2011.pdf

Table of Content:
1 10ELECTRICAL EQUIPMENT
1.1 Using support
2 F0 GENERAL
2.1 List of CLAAS COMPONENT NUMBERS (CCN)
2.2 Connector list
2.3 General wiring
2.4 Bundle List
2.5 List of mass points
2.6 Fuse and electronic boards
2.7 Upper cabin fuse board V21-3
3 F1FUNCTIONAL CHARTS
3.1 Front work lights in the upper part of the cab
3.2 Rear work lights in the upper part of the cab
3.3 Position lights and license plate
3.4 Low beam
3.5 Dipped beam headlights with switching in the upper part of the cabin
3.6 High beam
3.7 Stop lights
3.8 Turning lights
3.10 Direction indicators and warning lights
3.11 Instrument lighting
3.12 Ventilation controlinkage
3.15 Front power take-off shaft
3.16 Rear power take-off shaft
3.17 Starting system and load
3.18 Preheat
3.19 Driving forward – Driving reverse
3.20 Auto speed ranges
3.21 4 wheel drive control
3.22 Differential control
3.23 Hydraulic pressures – Oil filter clogging
3.24 Creeping speed range
3.25 Gear oil temperature
3.26 Quadrishift
3.27 Working/Transport Mode
3.28 Auto Speed Range and Quadrishift Control
3.2″Powertrain CAN Bus”
3.36 “CLAAS vehicle CAN bus”
3.37 Hydraulic CAN bus
3.38 Power supply before socket
3.39 Power supply after socket
3.41 Power supply for drive system modules (“TR1”, “TR2”, “TR3”)
3.42 Power supply to the rear linkage module (“REH”) and control panel
3.43 Engine module power supply (“ENG”)
3.44 Diagnostics socket power supply
3.45 Power supply to the electrical distributor module (“VALVE”) – Modulehydraulic (HYD)
3.46 Dashboard Module Power Supply (“DBD”)
3.47 25 A socket (cabin)
3.48 Charger socket power
3.49 Pneumatic braking system
3.50 Braking CUNA
3.51 Handbrake
3.52 Pneumatic seat
3.53 Occupancy sensor
3.54 Theoretical travel speed and drive status
3.55 Fuel gauge
3.56 Brake fluid level
3.57 Oil pressure – Air filter clogged -Coolant temperature
3.58 Electronic injection – 4-cylinder engine
3.59 Engine speed
3.60 Adjustment, dashboard display
3.61 Dashboard selector “C.I.S.”
3.62 Control of electrohydraulic distributors
3.63 Performance Accumulation
4 F2CONNECTOR DIAGRAMS
4.1 Connector J003 – Board V21-1
4.2 Connector J004 – Board V21-1
4.3 Connector J005 – Board V21-1
4.4 Connector J006 – CAN network
4.5 Connector J007 – CAN network
4.6 J008 Connector – PSI Board
4.7 Connector J009 – Compressor
4.8 Connector J010 – Pressure switch
4.9 Connector J011 – Pressure switch
4.10 Connector J013 – Air filter clogged
4.11 Connector J014 – Alternator
4.12 Connector J015 – Alternator B-
4.13 Connector J016 – Alternator D+
4.14 Connector J017 – Starter
4.15 Connector J018 – Starter
4.16 Connector J019 – Alternator W
4.17 Connector J020 – Cabin ground
4.18 Connector J021 – Cabin ground
4.19 Connector J022 – Ground starter
4.20 Connector J023 – Cabin ground
4.21 Connector J024 – Ground starter
4.22 Connector J025 – Fuse, pre-heating
4.23 Connector J026 – Board V21-1
4.24 Connector J028 – Preheating resistance
4.25 Connector J029 – Preheating relay
4.26 Connector J030 – Preheating relay
4.27 Connector J031 – Preheating relay
4.28 Connector J032 – Electric valve – Rear window washer
4.29 Connector J033 – Electric valve – Windshield washer
4.30 Connector J034 – Ground preheating
4.31 Connector J035 – Injection sensor
4.32 Connector J036 – Water in diesel sensor
4.33 Connector J037 – Engine ECU
4.34 Connector J038 – Common Rail Pressure Sensor
4.35 Connector J040 – Engine water temperature sensor
4.36 Connector J041 – Engine speed sensor
4.37 Connector J043 -Diesel temperature
4.38 Connector J044 – Board V21-3 – Upper cabin
4.39 Connector J044 – Board V21-3 – Upper cabin
4.40 Connector J046 – Board V21-3 – Upper cabin
4.41 Connector J047 – Board V21-3 – Upper cabin
4.42 Connector J048 – Board V21-1
4.43 Connector J048 – Board V21-3 – Upper cabin
4.44 Connector J049 – Board V21-3 – Upper cabin
4.45 Connector J050 – Transmission pressure switch
4.46 Connector J051 – Rear power take-off shaft speed sensor
4.47 Connector J052 – Board V21-1
4.48 Connector J053 – Electric valve 98 l/min
4.49 Connector J054 – Engine speed sensor
4.50 Connector J056 – Rear PTO brake electric valve
4.51 Connector J057 – Rear PTO shaft electric valve
4.52 Connector J058 – Differential lock electric valve
4.53 Connector J059 – Electric valve 4 drive wheels
4.54 Connector J060 – Speed range electric valve EV3
4.55 Connector J061 – Speed range electric valve EV4
4.56 Conneitch C2
4.63 Connector J069 – Switch C1
4.64 Connector J070 – Oil temperature sensor
4.65 Connector J071 – Reverse electric valve
4.66 Connector J072 – Forward electric valve
4.67 Connector J073 – Electric valve 2-C
4.68 Connector J074 – Electric valve 2-A
4.69 Connector J080 – Trailer socket
4.70 Connector J081 – Position sensor
4.71 Connector J082 – Left rod
4.72 Connector J083 – Right rod
4.73 Connector J084 – Lift Valve
4.74 Connector J085 – Lowering valve
4.75 Connector J086 – Fuel gauge
4.76 Connector J087 – Ventilation control
4.77 Connector J088 – Ventilation control (manual air conditioning)
4.78 Connector J088 – Ventilation control (without air conditioning)
4.79 Connector J089 – Ventilation control
4.80 Connector J090 – Ventilation control
4.81 Connector J091 – Motofan
4.82 Connector J092 – BOC
4.83 Connector J093 – Torque inverter potentiometer
4.84 Connector J094 – Ignition switch
4.85 Connector J095 – Ignition switch
4.86 Connector J096 – Signaling kit
4.87 Connector J097 – Torque inverter control
4.88 Connector J098 – Dashboard
4.89 Connector J099 – Dashboard
4.90 Connector J100 – Dashboard
4.91 Connector J101 – CAN branch Manual air conditioning
4.92 Connector J101 – CAN Branch
4.93 Connector J102 – Left stop switch
4.94 Connector J103 – Left stop switch
4.95 Connector J104 – Stop switch right
4.96 Connector J105 – Stop switch right
4.97 Connector J106 – Windshield wiper motor
4.98 Connector J107 – Wiper lever
4.99 Connector J110 – Cab top plate
4.100 Connector J112 – Left side work light
4.101 Connector J113 – Left side work light
4.102 Connector J114 – Left side work light
4.103 Connector J115 – Right side work light
4.104 Connector J116 – Right side work light
4.105 Connector J117 – Right side work light
4.106 Connector J118 – Cabin ground
4.107 Connector J124 – Ground fan
4.108 Connector J125 – Cabin ground
4.109 Connector J127 – Air conditioning control – recirculation
4.110 Connector J128 – Air conditioning thermostat
4.111 Connector J129 – Accelerator pedal potentiometer
4.112 Connector J131 – Right front work light
4.113 Connector J132 – Right front work light
4.114 Connector J133 – Left front work light
4.115 Connector J134 – Left front work light
4.116 Connector J136 – Ceiling light left
4.117 Connector J138 – Ceiling light right
4.118 Connector J139 – Antenna ground
4.119 Connector J140 – Car radio
4.120 Connector J141 – Car radio
4.121 Connector J142 – Rear work light control button
4.122 Connector J143 – Rear work light control button
4.123 Connector J144 – Front work light control button
4.124 Connector J145 – Front work light control button
4.125 Connector J146 – Windshield wiper/washer lever
4.126 Connector J148 – Rotating light control
4.127 Connector J149 – Rotating light control
4.128 Connector J150 – Right speaker
4.129 Connector J151 – Right rear external work light
4.130 Connector J153 – Rear window wiper motor
4.131 Connector J154 – Left speaker
4.132 Connector J155 – Left rear external work light
4.133 Connector J158 – 4 wheel drive control
4.134 Connector J159 – Differential control
4.135 Connector J160 – Electric valve control – 98 l/min
4.136 Connector J160 – Electric valve lamp – 98 l/min
4.137 Connector J162 – Rear PTO clutch control
4.138 Connector J163 – PTO control automatic
4.139 Connector J164 – Operating/transport mode selection
4.140 Connector J165 – Rear PTO shaft speed switch 1,000 rpm
4.141 Connector J166 – Rear PTO shaft speed switch 1,000 rpm
4.142 Connector J167 – Rear PTO switch ECO
4.143 Connector J168 – Rear PTO switch ECO
4.144 Connector J169 – Creeping speed switch
4.145 Connector J170 – Creeping speed switch
4.146 Connector J172 – Knob
4.147 Connector J173 – Calculator Auto5
4.148 Connector J174 – Calculator Auto5
4.149 Connector J175 – Calculator Auto5
4.150 Connector J176 – Ground box
4.151 Connector J177 – Diode
4.152 Connector J178 – Diode
4.153 Connector J181 – Engine oil pressure
4.154 Connector J182 – Resistance box
4.155 Connector J184 – CAN Branch
4.156 Connector J185 – CAN Branch
4.157 Connector J186 – CAN Branch
4.158 Connector J187 – Operating/Transport Mode Selection
4.159 Connector J188 – Speed sensor CAM
4.160 Connector J190 – Base shunt
4.161 Connector J191 – Auto5 Module – Electro-hydraulic lift
4.162 J192 Connector – TCE15T Module
4.163 Connector J194 – CAN Branch +R
4.164 Connector J196 Rear PTO brake control button
4.168 Connector J204 – Front PTO button
4.169 Connector J205 – Base shunt
4.170 Connector J209 – Ground base
4.171 Connector J210 – Handbrake
4.172 Connector J211 – Handbrake
4.173 Connector J212 – Seat
4.174 Connector J213 – Warning control
4.175 Connector J214 – Door rebate – Left
4.176 Connector J215 – Door rebate – Left
4.177 Connector J216 – Door rebate – Right
4.178 Connector J217 – Door rebate – Right
4.179 Connector J218 – Warning indicator lamps
4.180 Connector J219 – + AVC – Upper cab
4.181 Connector J220 – Ground jumper
4.182 Connector J221 – Ground jumper
4.183 Connector J223 – CAN Branch
4.184 Connector J224 – Diagnostics socket
4.185 J225 Connector – Board V21-1
4.186 J226 Connector – Board V21-1
4.187 Connector J227 – UBM Hydraulika
4.188 J228 connector – UBM Hydraulika
4.189 Connector J229 – Joystick
4.190 Connector J230 – Button HYD
4.191 Connector J231 – Starter
4.192 Connector J232 – Diode
4.193 Connector J233 – Diode
4.194 Connector J236A – Cigarette lighter
4.195 Connector J237 – CAN Branch +R
4.196 Connector J238 – CAN Branch +R
4.197 Connector J239 – Indicator light HYD
4.198 Connector J241 – DEH Harness – DEH Harness Mayeux
4.199 Connector J243 – CAN Branch +R
4.200 Connector J244 – Electro-hydraulic distributor
4.201 Connector J245D – Right rear warning lamps
4.202 Connector J245G – Left rear warning lights
4.203 Connector J246D – PTO button “on/off”
4.204 Connector J246G – PTO button “on/off”
4.205 Connector J247D – Electrohydraulic lift control button
4.206 Connector J247G – Electrohydraulic lift control button
4.207 Connector J248D – Electrohydraulic lift lowering control button
4.208 Connector J248G – Electrohydraulic lift lowering control button
4.209 Connector J249D – Power take-off shaft stop button, right fender
4.210 Connector J249G – Power take-off shaft stop button, left fender
4.211 Connector J250 – Ground starter
4.212 Connector J251 – Dashboard selector
4.213 Connector J252 – Rear work lights
4.214 Connector J253 – Rear work lights
4.215 J254 Connector – Board V21-1
4.216 Connector J255 – Charger power
4.217 Connector J256 – Left low beam
4.218 Connector J257 – Right dipped beam
4.219 Connector J258 – License plate light
4.220 Connector J259 – Speed tfilter clogged
4.224 Connector J276 – Injection pump
4.225 Connector J277 – Air Pressure Switch
4.226 Connector J278 – Brake pressure switch CUNA
4.227 Connector J279 – Brake Electric Valve CUNA
4.228 Connector J280 – Terminal connection + battery
4.229 Connector J281 – Terminal connection + battery
4.230 Connector J283 – Tractor speed sensor
4.231 Connector J291 – CAN Branch CLAAS
4.232 J295 Connector – Pin
4.233 Connector J296 – Autoshift
4.234 Connector J297 – Autoshift
4.235 Connector J300 – Terminal + (battery)
4.236 Connector J300 – Terminal + (battery)
4.237 Connector J301 – Terminal – (battery)
4.238 Connector J307 – Air Brake Electric Valve
4.239 Connector J313 – Fuse
4.240 Connector J320 – Cab top plate
4.241 Connector J322 – Cab top plate
4.242 Connector J338 – Electrical socket for tools
4.243 Connector J339 – Electrical socket for tools
4.244 Connector J340 – Electrical socket for tools
4.245 Connector J341 – Electrical socket for tools
4.246 Connector J342 – Electrical socket for tools
4.247 Connector J365 – Front power take-off shaft
4.248 Connector J367 – Cab top plate
4.249 Connector J375 – Cab top plate
4.250 Connector J379 – Brake fluid
4.251 Connector J400 – Left high beam
4.252 Connector J401 – Left high beam
4.253 Connector J402 – Left low beam
4.254 Connector J403 – Left low beam
4.255 Connector J404 – Right high beam
4.256 Connector J405 – Right high beam
4.257 Connector J406 – Horn
4.258 Connector J407 – Horn
4.259 Connector J408 – Right low beam
4.260 Connector J409 – Right low beam
4.261 Connector J410 – Dipped beam up/down switch
4.262 Connector J411D – Right turn light
4.263 Connector J411G – Left turn light
4.264 Connector J412D – Ground turning light
4.265 J412G Connector – Ground turning light
4.266 Connector J433 – Electro-hydraulic distributor n+1
4.267 Connector J434 – Electro-hydraulic distributor n
4.268 J435 Connector – Board V21-1
4.269 Connector J436 – Battery
4.270 Connector J438 – Oil filter clogged – (suction)
4.271 Connector J439 – Speed Range Electric Valve EV1
4.272 Connector J440 – Timing sensor
4.273 Connector J441 – CAN
4.274 Connector J442 – Electro-hydraulic distributor
4.275 Weave N001
4.276 Weave N002
4.277 Weave N003
4.278 Weave N004
4.279 Weave N005
4.280 Weave N006
4.281 Weave N007
4.282 Weave N008
4.283 Weave N009
4.284 Weave N010
4.285 Weave N011
4.286 Weave N012
4.287 Weave N013
4.288 Weave N014
4.289 Weave N015
4.290 Weave N016
4.291 Weave N017
4.292 Weave N018
4.293 Weave N019
4.294 Weave N020
4.295 Weave N022
4.304 Weave N034
4.305 Weave N035
4.306 Weave N036
4.307 Weave N037
4.308 Weave N038
4.309 Weave N039
4.310 Weave N040
4.311 Connector P001 – J001 – Intermediate connector
4.312 Connector P002 – J002 – Adapter
4.313 Connector P012 – J012 – Adapter
4.314 Connector P027 – J027 – Adapter
4.315 Connector P039 – J039 – Adapter
4.316 Connector P042 – J042 – Adapter
4.317 Connector P045 – J045 – Adapter
4.318 Connector P079 – J079 – Adapter
4.319 Connector P119 – J119 – Adapter
4.320 Connector P120 – J120 – Adapter Connector Manual air conditioning
4.321 Connector P120 – J120 – Adapter
4.322 Connector P121 – J121 – Adapter
4.323 Connector P122 – J122 – Adapter
4.324 Connector P123 – J123 – Adapter Connector Manual air conditioning
4.325 Connector P123 – J123 – Adapter
4.326 Connector P126 – J126 – Adapter
4.327 Connector P135 – J135 – Adapter
4.328 Connector P137 – J137 – Adapter
4.329 Connector P156 – J156 – Adapter
4.330 Connector P157 – J157 – Adapter
4.331 Connector P179 – J179 – Adapter
4.332 Connector P180 – J180 – Adapter
4.333 Connector P189 – J189 – Adapter
4.334 Connector P193 – J193 – Adapter
4.335 Connector P195 – J195 – Adapter
4.336 Connector P198 – J198 – Adapter
4.337 Connector P207 – J207 – Adapter
4.338 Connector P208 – J208 – Adapter
4.339 Connector P236 – J236 – Adapter
4.340 Connector P242 – J242 – Adapter
4.341 Connector P271 – J271 – Adapter
4.342 Connector P289 – J289 – Adapter
4.343 Connector P298 – J298 – Adapter
4.344 Connector P306 – J306 – Adapter
4.345 Connector P306 – J306 – Adapter
4.346 Connector P437 – J437 – Adapter
5 F3LOCATION DIAGRAMS
5.1 01 – Lower cabin harness
5.2 02 – Front bulkhead harness (without air conditioning)
5.3 02 – Front partition harness (manual air conditioning)
5.4 03 – Fenders harness
5.5 04 – Upper cabin harness
5.6 07 – Cabin power harness
5.7 09 – Quadrishift drivetrain harness
5.8 10 – Engine harness
5.9 11 – Radiator harness
5.10 12 – Electronic injection harness
5.11 13 – Drive control harness
5.12 14 – Electrohydraulic lift control harness
5.13 15 – Electrohydraulic lifter harness
5.14 22 – Low beam switching harness
5.15 25 – Air brake harness
5.16 25 – CUNA braking beam and pneumatic
5.17 26 – Rotating light beam
5.18 27 – Internal power harness
5.19 40 – Level beam
5.20 41 – Alternator adapter harness
5.21 42 – Electrohydraulic distributor terminal harness
5.22 43 – Electrohydraulic distributor connection harness
5.23 44 – Electrohydraulic distributor harness
5.24 47 – Air temperature sensor adapter harness
5.25 49 – Electrical socket harness tool
5.26 52 – Cigarette lighter harness
5.27 58 – Window washer container harness
5.28 60 – Low beam shunt
5.29 67 – Pre-heating harness
5.30 68 – Electrohydraulic distributor control harness
5.31 69 – Front power take-off shaft extension harness
5.32 76 – Power Adaptation Harness
5.33 81 – Front power take-off shaft control harness