Claas AXION 840-810 CMATIC (A31) Tractors Repair Manual PL

File List:

– Size(0.4 MB) 10/13/2010.pdf
– Size(0.4 MB) 10/04/2010.pdf
– Size(1.4 MB) 6.24.2011.pdf
– Size(11 MB) 10/13/2010.pdf
– Size(12.3 MB) 11/26/2010.pdf
– Size(12.6 MB) 10/22/2012.pdf
– Size(13.4 MB) 11/26/2010.pdf
– Size(14.5 MB) 11/26/2010.pdf
– Size(18.4 MB) 11/26/2010.pdf
– SizeZ-ACTIV

Size(0.4 MB) 10/04/2010.pdf

Table of Content:
2 Fastening and sealing means
3 Pneumatic systems
4 Water lines
5 Standardized tightening torques (except support specific torques)
5.3 Hydraulic fittings standard DIN 3865

Size(1.4 MB) 6.24.2011.pdf

Table of Content:
1 C_TEST METHODS – CLAAS COMPONENT NUMBER (CCN)
1.1 TEST METHODS

Size(11 MB) 10/13/2010.pdf

Table of Content:
1 D Front part equipment
1.1 D1 SUSPENSION FRONT AXLE
1.2 D2 MECHANISMS MANAGEMENT
1.3 D3 4 DRIVE WHEELS
1.4 D4 RIGID FRONT AXLE

Size(12.3 MB) 11/26/2010.pdf

Table of Content:
1 E_HYDRAULIC SYSTEM
1.1 E1 GENERAL
1.2 E2 HYDRAULCMATIC
1.1 B1 GEARBOX CMatic

Size(13.4 MB) 11/26/2010.pdf

Table of Content:
1 A – DPS TIER III ENGINE
1.1 A1 ENGINE

Size(14.5 MB) 11/26/2010.pdf

Table of Content:
1 C REAR AXLE
1.1 C1 GENERAL
1.2 C2 SMALLER GEAR DRIVE WHEEL
1.3 C3 DIFFERENTIAL
1.4 C4 REAR POWER TAKE-OFF SHAFT
1.5 C5 AUTOMATIC BRAKE
1.6 C6 WORK BRAKE 40 AND 50 HP/H
1.7 C7 VAGINHEXASHIFT
1.3 B3 REVERSHIFT
1.4 B4 AUTOMATIC SPEED RANGES
1.5 B5 SHAFT 4 DRIVE WHEELS
1.6 B6 SLOW SPEED RANGE

Size(21.4 MB) 11/26/2010.pdf

Table of Content:
1 E – HYDRAULICATION
1.1 E1 HYDRAULICATION
1.2 E2 REAR LIFTING LIFT (FOR NO. A0901559)
1.3 E3 REAR LINKAGE (FROM NO. A0901560)
1.4 E4 AUXILIARY DISTRIBUTORS (FOR NO. A0901559)
1.5 E5 HYDRAULIC DISTRIBUTORS (FROM NO. A0901560)
1.6 E6 STEERING

Size(22.6 MB) 10/13/2010.pdf

Table of Content:
1 C_REAR AXLE – REAR POWER TAKE-OFF SHAFT – BRAKE
1.1 C1 REAR AXLE
1.2 C2 REAR POWER TAKE-OFF SHAFT
1.3 C3 PARK BRAKE
1.4 C4 BRAKE
1.5 C5 HIGH PRESSURE BRAKE
1.6 C6 TRAILER HYDRAULIC BRAKING
1.7 C7 AIR BRAKEING PWLP
1.1 G1 ERROR CODE LIST
1.2 G2 CONTROL BOARD WLP?CLAAS COMPONENT NUMBER ELECTRONIC SYSTEM

Size(4.5 MB) 10/13/2010.pdf

Table of Content:
1 J_FRONT LIFT – FRONT POWER TAKE-OFF SHAFT
1.1 J1 FRONT LIFT AND MOUNTING POINTS
1.2 J2 FRONT POWER TAKE-OFF SHAFT ZUIDBERG

Size(40.8 MB) 1/21/2013.pdf

Table of Content:
1 ELECTRICAL EQUIPMENT FOR TRACTOR NO. A0902431
1.1 Using support
1.2 F0 GENERAL
1.3 F1 FUNCTIONAL CHARTS
1.4 F2 – ELECTRICAL SYSTEM
1.5 F3 – PLACEMENT DIAGRAM

Size(42.8 MB) 3.6.2015.pdf

Table of Content:
1 A DPS TIER III ENGINE
1.1 A1 GENERAL
1.2 A2 CYLINDER HEAD AND VALVES
1.3 A3 CYLINDER SLEEVES, PISTONS AND CONNECTING RODS
1.4 A4 FLYWHEEL, BEARING AND CRANKSHAFT
1.5 A5 TIMING AND BALANCE SHAFT
1.6 A6 INJECTION UNIT
1.7 A7 LUBRICATION SYSTEM

Size(48.1 MB) 1/21

Size(53.1 MB) 7/15/2011.pdf

Table of Content:
1 D FRONT AXLE
1.1 D1 NON-REINFORCED FRONT AXLES
1.2 D2 FRONT AXLES REINFORCED
1.3 D3 PTO SHAFT TRANSMISSION 4 DRIVE WHEELS

Size(68.1 MB) 11/05/2012.pdf

Table of Content:
1 A_PNEUMATIC ARCHITECTURE – CLAAS Component Number
1.1 PNEUMATIC ARCHITECTURE
2 DB-CCN_0011436840.pdf
2.1 B_ELECTRONIC ARCHITECTURE – CLAAS COMPONENT NUMBER
3 DC-CCN_0011436840.pdf
3.1 C_TEST METHODSCMATIC
1.1 B1 GENERAL
1.2 B2 CARTRIDGE CMatic
1.3 B3 GEARBOX HOUSING

Size(8.7 MB) 7/15/2011.pdf

Table of Content:
1 TOOL SET
1.1 00 0178 310 0
1.2 00 0178 320 0
1.3 00 1131 500 0
1.4 00 1131 512 0
1.5 00 1133 549 0
1.6 00 1134 143 0
1.7 00 1134 146 0
1.8 00 1135 095 0
1.9 00 1135 452 0
1.10 00 1136 020 0
1.11 00 1136 021 0
1.12 00 1136 024 0
1.13 00 1136 086 0
1.14 00 1136 138 0
1.15 00 1137 281 0
1.16 00 1137 282 0
1.17 00 1138 374 0
1.18 00 1139 143 0
1.19 00 1139 411 0
1.20 00 1139 414 0
1.21 00 1139 415 0
1.22 00 1139 416 0
1.23 00 1139 417 0
1.24 00 1139 421 0
1.25 00 1139 423 0
1.26 00 1139 426 0
1.27 00 1139 427 0
1.28 00 1139 428 0
1.29 00 1139 429 0
1.30 00 1139 430 0
1.31 00 1139 431 0
1.32 00 1139 432 0
1.33 00 1139 433 0
1.34 00 1139 434 0
1.35 00 1139 435 0
1.36 00 1139 436 0
1.37 00 1139 437 0
1.38 00 1139 438 0
1.140 876 0
1.42 00 1140 877 0
1.43 00 1140 878 0
1.44 00 1142 075 0
1.45 00 1142 076 0
1.46 00 1142 077 0
1.47 60 0500 531 0
1.48 60 0500 550 4
1.49 60 0500 550 7
1.50 60 0500 550 9
1.51 60 0500 551 0
1.52 60 0500 551 7
1.53 60 0500 552 0
1.54 60 0500 552 8
1.55 60 0500 553 2
1.56 60 0500 557 3
1.57 60 0500 557 6
1.58 60 0500 557 7
1.59 60 0500 559 4
1.60 60 0500 559 5
1.61 60 0500 572 6
1.62 60 0500 573 4
1.63 60 0500 615 3
1.64 60 0500 615 5
1.65 60 0500 630 9
1.66 60 0500 631 0
1.67 60 0500 631 1
1.68 60 0500 656 1
1.69 60 0500 656 4
1.70 60 0500 656 8
1.71 60 0500 657 6
1.72 60 0500 657 9
1.73 60 0500 670 3
1.74 60 0500 670 4
1.75 60 0500 675 8
1.76 60 0503 324 9
1.77 60 0503 325 0
1.78 60 0570 630 6
1.79 60 0571 280 0
1.80 60 0571 297 1
1.81 77 0000 389 8
1.82 77 0002 966 5
1.83 77 0002 966 6
1.84 77 0002 966 7
1.85 77 0003 448 4
1.86 77 0003 448 5
1.87 77 0005 436 1
1.88 77 0006 523 6
1.89 77 0138 803 1
1.90 77 0138 808 4
1.91 77 0138 811 1
1.92 77 0138 812 7
1.93 77 0138 818 0
1.94 77 0138 854 7
1.95 77 1113 251 7

Size(9.6 MB) 11/15/2010.pdf

Table of Content:
1 J_FRONT LIFT – FRONT POWER TAKE-OFF SHAFT
1.1 J1 FRONT LIFT
1.2 J2 FRONT POWER TAKE-OFF SHAFT (MAILLEUX ASSEMBLY)